• 0086-21-58386256
  • من الإثنين إلى السبت: 10:00 - 16:00 / يوم الأحد مغلق

Introduction to Quarry-Dust as Partial Replacement ...

 · quarry dust concrete is 10-12% more along with durability under sulphate and acid action. It also shown that the water absorption property of this concrete is slightly higher and lastly they have conclude that the replacement of natural sand with quarry dust, as full replacement in concrete is possible. To decide the water content and mix ...

أكمل القراءة

Use of Quarry Dust to Replace Sand in Concrete – An ...

 · clear picture that quarry dust can be utilized in concrete mixtures as a good substitute for natural river sand giving higher strength at 50% replacement. Index Terms- Concrete, quarry dust, river sand, compressive strength. I. INTRODUCTION oncrete is the most widely used composite material today.

أكمل القراءة

Partial Replacement of Sand with Quarry Dust in Concrete

This present work is an attempt to use Quarry Dust as partial replacement for Sand in concrete. Attempts have been made to study the properties of concrete and to investigate some properties of Quarry Dust the suitability of those properties to enable them to be used as partial replacement materials for sand in concrete.

أكمل القراءة

(PDF) Quarry Dust as an Efficient Substitute for Sand

replacement of sand with quarry dust. This experimental study presents the variation in the strength and durability propertie s of. concrete when replacing sand by …

أكمل القراءة

STUDY OF PARTIAL REPLACEMENT OF FINE AGGREGATE …

 · 1. The compressive strength of concrete is i use of quarry dust up to 10% replacement of sand. F rom 10% there is decrease in compressive strength 2. The split tensile strength concrete is increased by the use of quarry dust up to 0% replacement of fine aggrega te. From 10% there is a decrease in split tensile strength. 3.

أكمل القراءة

Studies on Quarry Dust as Partial Replacement of Fine ...

 · made to utilize quarry dust as a partial substitute for natural sand in producing concrete. Natural sand is replaced by Quarry dust at an interval of 5%, 10%, 15%, 20% and 25%. Mix proportions for M 20 concrete is prepared with reference to IS: 10262-2009 and IS: 456-2000 for the study of workability.

أكمل القراءة

Partial Replacement of Sand by Quarry Dust in Concrete

International Journal of Scientific and Research Publications, Volume 5, Issue 7, July 2015 1 ISSN 2250-3153 Partial Replacement of Sand by Quarry Dust in Concrete Sumit L. Chauhan, Raju A.Bondre Assistant Professor P. I. G. C. E. Nagpur Abstract- The paper describe the role of quarry dust In the of various complex silicates are formed, causing the mass to construction of …

أكمل القراءة

PARTIAL REPLACEMENT OF SAND BY QUARRY DUST IN …

 · concrete on partial replacement of sand by Quarry dust. This Experimental Study is applicable not only for Box Culverts but any other concrete works as well. 7. CONCLUSION From the experiment result it is concluded that the use of Quarry dust as fine aggregate gives better result in compressive strength.

أكمل القراءة

Behaviour of concrete by partial replacement of fine ...

 · 4. Conclusion. The present thesis works identified the effect of fragmentary replacement of Factory made Sand by Eco-Sand in concrete. Further, it had comparatively established various properties such as newly laid concrete and hardened concrete test for various percentages like 0%, 6%, 12%, 18%, 24 %and 30% respectively.

أكمل القراءة

(PDF) EFFECT OF QUARRY DUST AS PARTIAL …

Engineers have also used quarry dust as total replacement of sand in concrete. Quarry dust concrete for curing age of 28 days resulted higher compressive …

أكمل القراءة

Partial Replacement of Sand with Quarry Dust in Concrete ...

Partial Replacement of Sand with Quarry Dust in Concrete. -The reduction in the sources of natural sand and the requirement for reduction in the cost of concrete production has resulted in the increased need to identify substitute material to sand as fine aggregates in the production of concretes especially in Concrete.

أكمل القراءة

Replacement Of Sand With Quarry Dust In Concrete …

The project is about replacing sand in concrete production with quarry dust at varying percentage (0%, 25%, 50%, 75% and ) to check if the strength matches that of grade MIS with a mix ratio of I :2:4 and also the proportion which has the highest strength. The test carried out includes particle size analysis, slump test, and compressive test.

أكمل القراءة

Partial replacement of sand by granite powder in concrete

 · Partial replacement of sand by granite powder in concrete ... industries from Salem District, as alternative raw materials in the production of concrete. This granite powder ... reports the experimental study which investigated the influence …

أكمل القراءة

Quarry Mud as Partial Replacement for Fine Combination ...

 · Concrete production has resulted inside the accumulated that has to be com- ... trial to use Quarry mud as partial replacement for sand in concrete. alsTriare ... Physical properties of quarry dust and natural sand Quarry dust Natural sand Test method Specific gravity 2.54 - 2.60 2.60 IS 2386 (part III)-1963 ...

أكمل القراءة

The Utilization of Quarry Dust as Fine Aggregates in …

and suitability of the use of quarry dust for the partial replacement of sand in concrete. In the tenure of the study, the authors determined some important parametric properties of quarry dust. Also cubes for the partially replaced concrete of size 150mm x 150mm were casted, cured and then tested for the compressive strength.

أكمل القراءة

Partial Replacement of Sand by Quarry Dust in Concrete

 · Partial Replacement of Sand by Quarry Dust in Concrete Sumit L. Chauhan, Raju A.Bondre Assistant Professor P. I. G. C. E. Nagpur . Abstract- The paper describe the role of quarry dust In the construction of buildings and other structures to eliminate the demand of natural sand by using quarry waste to replace the use of natural sand.

أكمل القراءة

Quarry Dust Uses in a Construction Project - …

 · Quarry dust uses is not limited to highway projects, in construction projects that involves homes building, it is fast becoming popular too. Partial replacement of sand with quarry dust will make good concrete that is well …

أكمل القراءة

Investigation dust & cement by fly ash

incomplete replacement of 0%, 20%, 30%, 40% and 50% of sand by quarry dust. The durability of concrete was studied by immersing the concrete cube in …

أكمل القراءة

Study of Concrete Involving Use of Quarry dust as Partial ...

 · of quarry dust and the suitability of those properties to enable quarry dust (Celik et.al.,) to be used as partial replacement material for sand in concrete. The use of quarry dust in concrete is desirable because of its benefits such as useful disposal of by products, reduction of river sand consumption as well as increasing the strength

أكمل القراءة

Quarry dust as river sand replacement in cement masonry ...

The price of cement, river sand and quarry dust were obtained from the local market as SLR 1095 per 50 kg bag, SLR 5925 per cubic meter and SLR 5330 per cubic meter, respectively. Based on these, the cost of 1 kg cement, river sand and quarry dust were SLR 21.90, 3.53 and 3.25, respectively. Download : Download high-res image (254KB)

أكمل القراءة

[PDF] Utilization of Quarry Dust as a Partial Replacement ...

The use of crushed quarry dust as a partial replacement of river sand in concrete production was investigated in this study. This is expedient as quarry dust can be available at some locations with insufficient river sand for construction purposes. The use of quarry dust is also in concrete is also a measure necessary for improvement of concrete strength.

أكمل القراءة

PARTIAL REPLACEMENT OF CEMENT BY QUARRY DUST

 · observed that by 25% of partial replacement of cement with quarry dust improved hardened concrete properties. Keywords: Quarry dust, cement, water, aggregates. -----***-----1. INTRODUCTION Quarry dust is a waste product obtained from quarrying. It can be used as an effective filler material instead of cement. In the present study, the ...

أكمل القراءة

(PDF) Partial Replacement of Sand with Sawdust …

 · Abdullahi et al. (2013) studied the partial replacement of sand with sawdust in concrete production. Their results indicated the specific gravity of …

أكمل القراءة

CIVIL - EXPERIMENTAL PROJECTS - Majestic Project

Experimental Investigation on Replacement of Sand by Graded Quarry Dust in Concrete ... Use of Industrial Waste Red Mud in the Production of Self Compacting Concrete CEX043. Experimental Investigation of Fibre reinforced Concrete ... Experimental Investigation on Partial Replacement of Cement by Fly ash and Coarse Aggregate by Sea Shell in Concrete

أكمل القراءة

Use of Quarry Fine as Partial Replacement of Concrete as …

 · quarry dust the concrete produced compared well with normal concrete. He recommended quarry dust for replacement with sand in general concrete structures. Ilangovana et al., [12] studied the strength and durability properties of concrete containing quarry dust as fine aggregate and found that the compressive, flexural strength

أكمل القراءة

An Innovative Method of Replacing River Sand by Quarry ...

 · This paper deals with replacement of sand used in concrete as fine agg. regates by the waste generated by the stone quarry industry. This study has made . an attempt to partially replace quarry dust in place of sand in M35 grade concrete. On experimentation, it was found that the. partial replacement of sand . with. 10% of quarry du. st. has given

أكمل القراءة

Replacement of Sand in Concrete for Sustainable Building ...

 · Quarry dust can be partially used as an alternative to river sand, as fine aggregate in concrete production. It is basically a by-product of stone crushers produced during the crushing and screening process of coarse aggregates. The replacement of river sand with quarry dust enhances the compressive strength of the concrete to a limited extent.

أكمل القراءة

USE OF QUARRY DUST IN CONCRETE AS REPLACEMENT …

 · [2] Partial Replacement of Sand with Quarry Dust in Concrete Chandana Sukesh, Katakam Bala Krishna, P.Sri Lakshmi Sai Teja, S.Kanakambara Rao [3] EXPERIMENTAL INVESTIGATION ON QUARRYDUST CONCRETE WITH CHEMICAL ADMIXTURE [4] Use of crusehed granite fine as replacement ti river sand in concrete production, Manasseh JOEL, …

أكمل القراءة